ATCP 65.72(10) (10)Inspection by division; reinspection fee. The division may, in its discretion, inspect a dairy farm in response to any positive drug residue test report under sub. (8) or (9). The division shall charge a reinspection fee for the inspection under s. ATCP 65.02 (19). The division shall not charge a reinspection fee if it makes its inspection more than 3 weeks after the dairy plant operator reports the drug residue test result to the division.
ATCP 65.72(11) (11)Drug residue test results.
ATCP 65.72(11)(a) (a) Positive test result; general. For purposes of this section and s. ATCP 65.922, a drug residue test is considered positive if the detected amount of drug residue exceeds the action level specified for that drug under par. (b). The action levels, under par. (b), do not establish legal tolerances for drug residues in milk, nor do they preclude the department from taking enforcement action where drug residues are present at levels below these action levels.
ATCP 65.72(11)(b) (b) Specified drug tests; positive test result. In a test for any of the following drugs, the action level is exceeded whenever the drug residue level found in the test exceeds the level specified below:
ATCP 65.72(11)(b)1. 1. Ampicillin 10 ppb
ATCP 65.72(11)(b)2. 2. Amoxicillin 10 ppb
ATCP 65.72(11)(b)3. 3. Cephapirin 20 ppb
ATCP 65.72(11)(b)4. 4. Ceftiofur 100 ppb
ATCP 65.72(11)(b)5. 5. Cloxacillin 10 ppb
ATCP 65.72(11)(b)6. 6. Novobiocin 100 ppb
ATCP 65.72(11)(b)7. 7. Penicillin G 5 ppb
ATCP 65.72(11)(b)8. 8. Sulfadimethoxine 10 ppb
ATCP 65.72(11)(b)9. 9. Tetracyclines* 300 ppb
ATCP 65.72 Note Note: Action levels specified under this paragraph are based on tolerances and/or target testing levels specified by the United States food and drug administration, and identified in a memorandum from FDA's Milk Safety Branch, M-I-05-5, September 27, 2005. A copy of the memorandum is on file with the department, and is available upon request.
ATCP 65.72 Note For drugs identified with an asterisk (*), the levels in this paragraph are based on “safe levels" specified by FDA. "Safe levels" are merely enforcement guides and do not constitute legal tolerances. "Safe levels" are not binding on the courts or the department. They do not limit the department's discretion in any way, and they do not protect milk producers or milk itself from enforcement action. “Safe levels" do not constitute animal drug tolerances under section 512 (b) of the federal food, drug and cosmetic act.
ATCP 65.72(11)(c) (c) Test result presumed valid. For purposes of this section and s. ATCP 65.922, whenever a dairy plant operator reports a confirmed positive test result to the division under sub. (9), that test result is presumed to be valid. The milk producer may appeal the test result in an informal hearing under s. ATCP 65.928.
ATCP 65.72(12) (12)Laboratory reporting. A laboratory that performs tests under this section for a dairy plant operator may report the test results for the dairy plant operator.
ATCP 65.72(13) (13)Timely testing. Drug residue tests required under this section shall be completed within 72 hours after the tested milk, or any portion of the tested milk, was first collected from a dairy farm.
ATCP 65.72 Note Note: If a drug residue test is performed on a bulk load of milk collected from several dairy farms, the test must be completed within 72 hours after the bulk milk weigher and sampler collects milk from the first farm. Confirmation of positive drug residue screening tests, at a different laboratory than the laboratory which performed the screening tests, as required under s. ATCP 65.72 (3), must be completed within the same 72-hour period.
ATCP 65.72 History History: CR 14-073: cr. Register August 2016 No. 728, eff. 9-1-16; correction in (3) (e) made under s. 35.17, Stats., Register August 2016 No. 728.
ATCP 65.74 ATCP 65.74 Milk and dairy products; quality standards.
ATCP 65.74(1)(1)Milk held at dairy plant; bacterial count. The bacterial count of commingled grade A milk held at a dairy plant before pasteurization may not exceed 300,000 per ml. The bacterial count of grade B milk held at a dairy plant before pasteurization or processing may not exceed 750,000 per ml.
ATCP 65.74(2) (2)Pasteurized grade A dairy products.
ATCP 65.74(2)(a)(a) Bacterial counts in pasteurized grade A dairy products other than cultured dairy products may not exceed the following levels:
ATCP 65.74(2)(a)1. 1. 20,000 per ml., except as provided in subd. 2. and 3.
ATCP 65.74(2)(a)2. 2. 10,000 per g. for nonfat dry milk.
ATCP 65.74(2)(a)3. 3. 30,000 per ml. for condensed milk, whey, whey products, and dried whey.
ATCP 65.74(2)(b) (b) Coliform counts in pasteurized grade A dairy products may not exceed 10 per ml. or per gram, except that coliform counts in bulk milk tanker shipments of pasteurized grade A dairy products may not exceed 100 per ml.
ATCP 65.74(2)(c) (c) In pasteurized grade A milk without added flavors or ingredients, other than vitamins, there shall be fewer than 350 milliunits of phosphatase per liter as determined by the Fluorophos ALP method, the Charm Paslite Alkaline Phosphatase method or another test method approved by the department.
ATCP 65.74(2)(d) (d) The yeast and mold count of pasteurized cottage cheese may not exceed 10 per gram.
ATCP 65.74(3) (3)Pasteurized grade b dairy products.
ATCP 65.74(3)(a)(a) Bacterial counts in pasteurized grade B dairy products, other than cultured dairy products or frozen desserts containing nuts or other inclusions, may not exceed the following levels:
ATCP 65.74(3)(a)1. 1. 20,000 per ml., except as provided in subd. 2. or 3.
ATCP 65.74(3)(a)2. 2. 30,000 per ml. for condensed milk, whey, whey products, dried whey, and nonfat dry milk.
ATCP 65.74(3)(a)3. 3. 50,000 per gram for frozen desserts, except that the bacterial count for frozen-dessert mixes may not exceed 20,000 per gram.
ATCP 65.74(3)(b) (b) Coliform counts in pasteurized grade B dairy products, other than grade B dairy products made with natural or added cultures and all natural cheeses, may not exceed 10 per ml. or per gram, except that coliform counts in bulk milk tanker shipments may not exceed 100 per ml.
ATCP 65.74(4) (4)Fortified dairy products. Whenever milk or a fluid milk product is fortified with vitamin A or D the fortification shall comply with Appendix O of the PMO.
ATCP 65.74(5) (5)Pathogen confirmed in ready-to-eat dairy product; sale prohibited. A dairy plant operator may not sell or distribute any ready-to-eat dairy product in which a microbiological test or laboratory analysis has confirmed the presence of a pathogenic organism or toxin. Results of the microbiological test or laboratory test shall be reported to the division, under s. ATCP 65.46 (2).
ATCP 65.74 Note Note: Copies of PMO Appendix O are on file with the department and the legislative reference bureau. Copies may be obtained from the department at cost or online at:www.fda.gov/Food/GuidanceRegulation/GuidanceDocumentsRegulatoryInformation/Milk.
ATCP 65.74 History History: CR 14-073: cr. Register August 2016 No. 728, eff. 9-1-16.
ATCP 65.76 ATCP 65.76 Milk quality testing.
ATCP 65.76(1)(1)Required testing.
ATCP 65.76(1)(a)(a) A dairy plant operator shall test raw milk from dairy farms as required under this chapter.
ATCP 65.76(1)(b) (b) A dairy plant operator shall test milk and dairy products held or processed at a dairy plant for compliance with standards specified under s. ATCP 65.74 (1) to (4). The dairy plant operator shall test the milk and dairy products as often as necessary to provide reasonable statistical assurance of compliance.
ATCP 65.76(2) (2)Laboratory.
ATCP 65.76(2)(a) (a) Except as provided under par. (b), milk quality tests required under this chapter shall be performed in a laboratory that is all of the following:
ATCP 65.76(2)(a)1. 1. Approved by the department to conduct milk quality tests.
ATCP 65.76(2)(a)2. 2. Certified by the department under s. ATCP 77.03, or by an equivalent certifying agency in another state, to conduct milk quality tests.
ATCP 65.76(2)(b) (b) A laboratory that is not certified under s. ATCP 77.03 to perform a drug residue test under s. ATCP 65.72 may perform that test as a screening test if all of the following apply:
ATCP 65.76(2)(b)1. 1. The department has approved that laboratory to perform that screening test under s. ATCP 77.23 (1).
ATCP 65.76(2)(b)2. 2. The department has approved the person who performs the screening test under s. ATCP 77.23 (2).
ATCP 65.76(2)(b)3. 3. A different laboratory performs a confirmatory test if the screening test result is positive for drug residue. The laboratory performing the confirmatory test shall be certified to do so under s. ATCP 77.03. The laboratory shall perform the confirmatory test on the same test sample using the same or an equivalent test method and shall complete the confirmatory test within the time period specified in s. ATCP 65.72 (8).
ATCP 65.76(2)(c) (c) The department may withdraw its approval under par. (a) or (b) for cause, including false or inaccurate test results or reports, or failure to conduct tests according to required procedures.
ATCP 65.76(3) (3)Analysts.
ATCP 65.76(3)(a) (a) Except as provided in par. (b) or (c), no individual may perform a milk test under ss. ATCP 65.70 and 65.72 unless the department has certified that individual under s. ATCP 77.22 to perform that test.
ATCP 65.76(3)(b) (b) Pursuant to s. ATCP 77.23 (2), the department may approve an individual to perform a drug residue test under s. ATCP 65.72 as a screening test, even though the individual is not certified under s. ATCP 77.22 to perform that test as a confirmatory test.
ATCP 65.76(3)(c) (c) Bulk load tests for drug residues under s. ATCP 65.72 shall be conducted at the receiving dairy plant by any of the following:
ATCP 65.76(3)(c)1. 1. An individual approved by the department to conduct drug residue tests.
ATCP 65.76(3)(c)2. 2. An individual who performs drug residue tests only under the direct supervision of an individual approved and certified under subd. 1.
ATCP 65.76 Note Note: A laboratory performing milk quality tests must be certified under ch. ATCP 77.
ATCP 65.76(4) (4)Test methods. Milk testing under ss. ATCP 65.70 and 65.72 shall use test methods prescribed in the applicable FDA 2400 series laboratory evaluation forms, published by the United States department of health and human services, public health service, food and drug administration, that are in effect on February 1, 2008. If no FDA form applies, testing shall be conducted according to methods prescribed in the "Standard Methods for the Examination of Dairy Products," 17th Edition (2004), or in "Official Methods of Analysis of AOAC International," 18th Edition (2005).
ATCP 65.76 Note Note: Copies of the FDA 2400 series laboratory evaluation forms in effect on February 1, 2008, are on file with the department and the legislative reference bureau. To find out how to obtain a copy of these forms, you may contact the department at the following address:
ATCP 65.76 Note Wisconsin Department of Agriculture, Trade and Consumer Protection
ATCP 65.76 Note Division of Food Safety
ATCP 65.76 Note Laboratory Certification Program
ATCP 65.76 Note P.O. Box 8911, Madison, WI 53708-8911
ATCP 65.76 Note Telephone: (608) 224-4712
ATCP 65.76 Note The American Public Health Association's “Standard Methods for the Examination of Dairy Products," 17th Edition (2004), is on file with the department and the legislative reference bureau and may be obtained from the American Public Health Association, Inc., 800 I Street, NW, Washington, D.C. 20001, telephone 202-777-2742, website www.apha.org.
ATCP 65.76 Note The “Official Methods of Analysis of AOAC International," 18th Edition (2005), is on file with the department and the legislative reference bureau and may be obtained from AOAC International, 2275 Research Blvd., Rockville, MD 20850, telephone 800-379-2622, website https://www.aoac.org .
ATCP 65.76(5) (5)Bacteria counts. Bacteria counts required under s. ATCP 65.70 and bacteria counts that may affect the amount paid to a milk producer shall be obtained by means of a standard plate count, plate loop count, or petrifilm aerobic count method.
ATCP 65.76(6) (6)Drug residues. Drug residue tests required under s. ATCP 65.72 shall be performed according to s. ATCP 65.72.
ATCP 65.76(7) (7)Somatic cells. Somatic cell counts required under s. ATCP 65.70 (4) and somatic cell counts that may affect the amount paid to a milk producer shall be obtained by means of a direct microscopic somatic cell count or an electronic somatic cell count. The Pyronin Y-Methyl green stain test may be used in place of a direct microscopic somatic cell count or electronic somatic cell count for goat milk and shall be used to confirm a direct microscopic somatic cell count or electronic somatic cell count on goat milk that exceeds 1,000,000 per ml.
ATCP 65.76(8) (8)Testing deadlines. A milk quality test shall be conducted within the time period specified by the test method.
ATCP 65.76 History History: CR 14-073: cr. Register August 2016 No. 728, eff. 9-1-16; correction in (2) (a) 2. made under s. 35.17, Stats., Register August 2016 No. 728.
ATCP 65.78 ATCP 65.78 Milk quality test samples.
ATCP 65.78(1)(1)General.
ATCP 65.78(1)(a)(a) Whenever a dairy plant operator performs a milk quality test on a bulk milk shipment from a milk producer, the dairy plant operator shall perform that milk quality test on a test sample collected under s. ATCP 82.12.
ATCP 65.78(1)(b) (b) Whenever a dairy plant operator performs a milk quality test on shipment of milk in cans from a milk producer, the dairy plant operator shall perform that milk quality test on a test sample collected under sub. (3).
ATCP 65.78(1)(c) (c) Notwithstanding pars. (a) and (b), a dairy plant operator may use a composite sample, under sub. (4), to perform a Babcock test for milkfat or to perform another milk quality test approved by the division under sub. (4). A composite sample shall be compiled from fresh milk samples collected under par. (a) or (b).
ATCP 65.78(1)(d) (d) This subsection does not apply to a bulk load test for drug residues under s. ATCP 65.72 (3).
ATCP 65.78(1)(e) (e) Upon reasonable notice from the division, a dairy plant operator shall provide the division with samples of producer milk collected under s. ATCP 65.38. The division may request samples once every 4 months, or more often as the department considers necessary for animal health and milk quality testing. Every sample shall be marked with the identification number of the individual producer from whom the sample was collected, and shall also indicate the date on which the sample was collected. A sample shall be kept at a temperature of 32° to 40° F. (0° F. to 4° C.) until it is transferred to the custody of the department.
ATCP 65.78(2) (2)Test samples refrigerated. At all times prior to testing, a test sample under sub. (1) shall be kept refrigerated at a temperature of 32 to 40° F. (0 to 4° C.). Test samples kept at a dairy plant or testing laboratory shall be kept in a refrigerated storage facility used only for storing test samples and laboratory supplies.
ATCP 65.78(3) (3)Collecting test samples from shipments of milk in cans.
ATCP 65.78(3)(a)(a) If a producer ships milk to a dairy plant in cans, rather than in bulk, the dairy plant operator shall collect a test sample from each milk shipment immediately after that milk shipment is transferred to the weigh tank at the dairy plant, and before it is commingled with any other milk shipment. The weigh tank shall be constructed so that milk poured into the weigh tank is completely mixed.
ATCP 65.78(3)(b) (b) If a weigh tank is not large enough to accommodate a producer's entire milk shipment, so that multiple weighings are needed, the dairy plant operator shall divide the shipment as evenly as possible between weighings and collect a sample from each weighing. The samples shall be of equal volume and shall be combined to form a single sample representing the entire shipment from the producer. The dairy plant operator may not split the contents of any single can of milk between weighings, but shall include all of the contents of that can in the same weighing.
ATCP 65.78(4) (4)Composite samples.
ATCP 65.78(4)(a) (a) A dairy plant operator may use a composite sample to perform a Babcock test for milkfat, but may not perform any other milk quality test on a composite sample except with the division's written authorization. A composite sample shall be compiled according to this subsection.
ATCP 65.78(4)(b) (b) A composite sample shall include a representative sample of milk from each of 2 or more milk shipments represented by the composite sample. No composite sample may include milk from more than 16 milk shipments. Each component sample included in the composite sample shall have the same volume and shall include at least 10 ml. of milk. A composite sample shall include at least 150 ml. of milk.
ATCP 65.78(4)(c) (c) A composite sample container shall have a capacity of at least 240 ml. The composite sample container shall include an effective permanent closure that is attached to the container. The composite sample container shall be marked to identify the producer and the milk shipments represented in the composite sample.
Loading...
Loading...
Published under s. 35.93, Stats. Updated on the first day of each month. Entire code is always current. The Register date on each page is the date the chapter was last published.